Product ID:USDA TREE MARKING PAINT GREEN VOC COMPLIANT 835-7324
MSDS Date:07/08/1994
FSC:8010
NIIN:01-380-1779
MSDS Number: BVNLB

SOUTHERN COATINGS, INC

SUMTER, SC 29151
US

Emergency Phone: 800-255-3924

Info Phone: 803-775-6351

Preparer: J.T. ROBERTSON

Cage: 6M840

SOUTHERN COATINGS

160 SUMTER, SC 29150 US

Telephone: 803-775-6351

Cage: 6M840

NAPHTHA, (PETROLEUM) HEAVY ALKYLATE

CAS: 64741-65-7

Fraction By Weight: 10.5%

MINERAL SPIRITS (VAPOR PRESSURE 2 MM HG @ 20C) (LFL 1.0;

CAS: 64475-85-0

RTECS: PY8240000

Fraction By Weight: 32.8%

OSHA PEL 100 PPM; 525 MG/M3

ACGIH TLV: 100 PPM; 525 MG/M3

STODDARD SOLVENT (LFL 0.8)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 0.3%

OSHA PEL 100 PPM; 525 MG/M3

ACGIH TLV: 100 PPM; 525 MG/M3

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 7.5%

OSHA PEL 10 MG/M3

ACGIH TLV: 10 MG/M3

3.36 LB/GAL LESS WATER & NEGLIGIBLY PHOTOCHEMICALLY

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INGESTION: GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING. ASPIRATION OF MATERIAL INTO LUNG MAY
CAUSE CHEMICAL PNEUMONITIS (CAN BE FATAL). INHALATION: NOSE OR
THROAT IRRITATION. ACUTE CENTRAL NERVOUS S YSTEM DEPRESSION
CHARACTERIZED BY HEADACHES, DIZZINESS, NAUSEA, CONFUSION. EYE:
IRRITATION. SKIN: DEFATTING, IRRITATION.
Effects of Overexposure:EFFECTS OF REPEATED OVEREXPOSURE: REPORTS HAVE
ASSOCIATED PROLONGED AND REPEATED OCCUPATIONAL OVEREXPOSURE TO
SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
INTENTIONAL MISUSE BY DELIBERATEL Y CONCENTRATING AND INHALING THE
CONTENTS MAY BE HARMFUL OR FATAL.

First Aid:INGEST:DON'T INDUCE VOMITING. CALL POISON CONTROL CTR,EMERG
ROOM,DR IMMED. INHAL:REMOVE TO FRESH AIR IMMED. IF BREATHING
STOPPED GIVE ARTIF RESP. KEEP WARM & QUIET. GET MED IMMED.
EYE:FLUSH W/LRG AMT WATER 15 MIN,LIFTING EYELIDS OCCASIONALLY. GET
MED AID. SKIN:REMOVE CONTAM CLOTHING. WASH SKIN W/SOAP & WATER. GET
MED AID IF IRRIT PERSISTS. NOTE TO DR:DIRECT TREATMENT AT SYMPTOM &
CLINICAL CONDITN.

Flash Point Method:SCC
Flash Point:105F,41C
Autoignition Temp:Autoignition Temp Text:475 F
Extinguishing Media:USE NFPA CLASS B EXTINGUISHERS (CO2, DRY CHEM,
ALCOHOL FOAM) TO EXTINGUISH FLAMM LIQ FIRE. POLYMER FOAM FOR LARGE
FIRES.
Fire Fighting Procedures:WEAR SCBA. WATER MAY BE INEFFECTIVE, USE TO
COOL (FOG NOZZLES PREFERRED) CONTAINERS TO PREVENT PRESSURE BUILDUP
& AUTOIGNITION OR EXPLOSION W/HEAT.
Unusual Fire/Explosion Hazard:OVEREXPOSURE TO DECOMP PRODUCTS MAY BE
HLTH HZD. KEEP CONTAINER CLOSED. KEEP FROM HEAT/IGNIT SOURCE.
CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:KEEP SPECTATORS AWAY. ELIMINATE IGNITION
SOURCES. DIKE & CONTAIN SPILL WITH INERT MATERIAL (SAND/EARTH)
TRANSFER LIQ TO COVERED METAL CONTAINERS FOR RECOVERY OR DISPOSAL
OR REMOVE WITH INERT ABSORBENT . USE NON-SPARKING TOOLS. PLACE USED
ABSORBENT *

Handling and Storage Precautions:DON'T STORE ABOVE 115F STORE LRG QTY
IN COMPLIANCE W/OSHA 29CFR1910.106. DON'T INGEST. CLOSE CONTAINER
AFTER EACH USE.
Other Precautions:EMPTY CONTAINERS MUST NOT BE WASHED & REUSED.
CONTAINERS SHOULD BE GROUNDED & BONDED TO RECEIVING CONTAINER. DO
NOT WELD, BRAZE OR CUT ON EMPTY CONTAINER. NEVER USE PRESSURE TO
EMPTY. DRUM IS NOT PRES SURE VESSEL.

Respiratory Protection:IN RESTRICTD VENT,NIOSH CHEM CARTRIDGE RESPRTR
MAY BE REQ'D. SPRAYING,ETC,MECHAN PREFILTER MAY ALSO BE REQ'D. IF
TLV EXCEEDED,USE FITTED NIOSH/MSHA RESPIRATOR W/APPROP PROTECT
FACTOR. SEE OSHA 29CFR19 10.134 RESP PROTECT&RESP PROTECT(ACGIH).
Ventilation:LOCAL EXHAUST VENT TO KEEP EXPOSURES BELOW NUISANCE DUST
LIMITS. SEE "INDUST VENT-MANUAL FOR RECOMM PRACTICES" (ACGIH).
Protective Gloves:SOLVNT IMPERM GLOVE-REQ'D REPEAT/PROLONG
Eye Protection:WEAR SAFETY SPECTACLES.
Other Protective Equipment:NOT LIKELY TO BE NEEDED
Supplemental Safety and Health

Boiling Pt:B.P. Text:165 TO 388F
Decomp Temp:Decomp Text:600F,316C
Vapor Density:> AIR
Spec Gravity:0.9
Viscosity:30-45S #4FORD
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Percent Volatiles by Volume:51

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS OR ALKALINE MATERIALS.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT AND SOURCES OF
IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE, AND CARBON
DIOXIDE.

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, &
LOCAL REGULATIONS. IF DISCARDED AS IS, IT IS NOT CLASSIFIED AS
HAZARDOUS WASTE UNDER RCRA. * IN COVERED METAL
CONTAINERS FOR DISPOSAL. PREVEN T CONTAMINATION OF SEWERS, STREAMS,
& GROUNDWATER.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.